SDS_2016_DuraKore_Powder

Public Channel / SDS

Share on Social Networks

Share Link

Use permanent link to share in social media

Share with a friend

Please login to send this document by email!

Embed in your website

Select page to start with

Post comment with email address (confirmation of email is required in order to publish comment on website) or please login to post comment

6. 1 of 5 DuraKore Powder ABBREVIATIONS: NA: Not Applicable ND: Not Determined NE: Not Established ppm: parts per million G: Gallon mg: M illigram L: Liter gm: Gram mol: Mole kg: Kilogram μ : Micro mm: Millimeter p Pico Pa: Pascals LC: Lethal Concentration LD: Lethal Dose TC: Toxic Concentration TD: Toxic Dose BOD: Biological Oxygen Demand COD: Chemical Oxygen Demand Lo: Lowest ThOD: Theoretical Oxygen Demand Tlm: Threshold Limit H: Hours M: Months D: Days Y: Years W: Weeks ACGIH: American Conference of Governmental Industrial Hygienist CPR: Controlled Product ’ s Regulation DSL: Canadian Domestic Substances List NDSL: Canadian Non - domestic Substance List IARC: International Agency for Research for Cancer NOEL: No Observed Effect Level NOAEL: No Observed Adverse Effect Level OSHA: Occupational Safety and Health Administration P EL: Permissible Exposure Limit TLV: Threshold Limit Value THIS MATERIAL SAFETY DATA SHEET IS PREPARED IN COMPLIANCE WITH FEDERAL REGULATIONS (29 CFR 1910.1200), THE COMMONWEALTH OF PENNSYLVANIA REGULATIONS (TITLE 34. CHAPTERS 301 - 323) AND CANADIAN WHMIS REGULATIONS, ANY APPLICABLE STATE AND LOCAL REGULATIONS SHOULD BE CONSULTED. THE ABOVE INFORMATION MAY BE BASED IN PART ON INFORMATION PROVIDED BY COMPONENT SUPPLIERS AND IS BELIEVED TO BE CORRECT AS OF THE DATE HEREOF. HOWEVER, NO WARRANTY OF MERCHANTABI LITY, FITNESS FOR ANY USE, OR ANY OTHER WARRANTY IS EXPRESSED OR IS TO BE IMPLIED REGARDING THE ACCURACY OF THESE DATA, THE RESULTS TO BE OBTAINED FROM THE USE OF THE MATERIAL, OR THE HAZARDS CONNECTED WITH SUCH USE. SINCE THE INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL AND WITH WHICH WE MAY BE UNFAMILIAR, AND SINCE DATA MADE AVAILABLE SUBSEQUENT TO THE DATE HEREOF MAY SUGGEST MODIFICATION OF THE INFORMATION, WE ASSUME NO RESPONSIBILITY FOR THE RESULT OF ITS USE. THIS INF ORMATION AND MATERIAL IS FURNISHED ON THE CONDITION THAT THE PERSON RECEIVING IT SHALL MAKE HIS/HER OWN DETERMINATION AS TO THE SUITABILITY OF THE MATERIAL FOR HIS/HER PARTICULAR PURPOSE AND ON THE CONDITION THAT HE/SHE ASSUME THE RISK OF HIS/HER USE THERE OF. Revised April 4, 2016

5. 1 of 5 DuraKore Powder Section 14 - Transport Information DOT/UN SHIPPING NAME: POLYMER, NOI DOT/UN CLASS: NA/UN NUMBER: PACKING GROUP: LABEL: IMDG CLASS: IMDG PG: CERCLA RQ: Section 15 - Regulatory Information SARA Reporting Requirements: NA SARA Threshold Planning Quantity: There are no specific Threshold Planning Quantities for the components of this product. TSCA Inventory Status: The components of this product are listed on the TSCA Inventory. For use in FDA regulated produc ts only. CERCLA Reportable Quantity (RQ): NA Other Federal Requirements: This product complies with the appropriate sections of the Food and Drug Administration's 21 CFR subchapter G (Cosmetics). Other Canadian Regulations: This product has be en classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR. The components of this product are listed on the DSL/NDSL. None of the components of this product are listed on th e Priorities Substances List. State Regulatory Information: This product may contain components that are covered under specific state criteria. RISK STATEMENTS: R36/37/38 – Irritating to eyes, respiratory system and skin. SAFETY STATEMENTS: S 3 – Keep in a cool place. S7 – Keep container tightly closed. S9 – Keep container in a well - ventilated place. S20 – When using do not eat or drink. S 29 – Do not empty into drains. S37/39 – Wear suitable gloves and eye/face protect ion. Section 16 - Additional Information HAZARDOUS MATERIAL IDENTIFICATION SYSTEM (HMIS) RATING: HEALTH: 1 FLAMMABILITY: 1 REACTIVITY: 0 PERSONAL PROTECTIVE EQUIPMENT: Gloves and Safety Glasses or Chemical Goggles. NATIONAL FIRE PROTECTION ASSOCIATION (NFPA) HAZARD IDENTIFICATION RATING: HEALTH: 1 FLAMMABILITY: 1 REACTIVITY: 0

1. 1 of 5 DuraKore Powder Safety Data Sheet Section 1 - Chemical Product and Company Identification Product Name: DuraKore Powder Company Identification: Reliance Dental Mfg., LLC. 5805 W. 117 th Place Alsip, IL 60803 For Product Information, call: 708 - 597 - 6694 For Medical Information, call: 800 - 535 - 5053 Section 2 - Composition, Information on Ingredients Item Chemical Name CAS # WT/WT% 01 Polymer 9003 - 42 - 3 60.0 - 100.0 02 Benzoyl Peroxide 94 - 36 - 0 0.0 - 5.0 ACGIH OSHA Company ITEM TLV - TWA TLV - STEL PEL TWA PEL CEILING Recommendation SKIN 01 10 mg/m 3 NE 15 mg/m 3 NE 15 mg/m 3 NE 02 5 mg/m 3 NE 5 mg/m 3 NE 5 mg/m 3 NE Section 3 - Hazards Identification EMERGENCY OVERVIEW: WARNING: For Polymer: OSHA classifies this material as Particulates, Not Otherwise Classified. Acute Hazards: Eyes: May be irritating to the eyes by gross overexposure, no matter how generated. Symptoms of overexposure may include redness, itching, irritation, and watering. Keep dust out of eyes. Ingestion: Not expected to cause any harmful effects. Inge stion of large amounts may be irritating if product is swallowed, may cause nausea, headache, vomiting and/or diarrhea. Skin: May be irritating to skin in some sensitive individuals, especially after prolonged and/or repeated contact . Inhalation: May be irritated by gross overexposure, no matter how generated. Chronic Hazards: None known. CARCINOGENICITY: IARC lists Benzoyl Peroxide as unclassifiable as to carcinogenicity to humans. None of the other components of t his material are listed by IARC, NTP, OSHA, or ACGIH as carcinogens. PRIMARY ROUTES OF ENTRY: Inhalation, Skin or Eyes. SECTION 4 - FIRST AID MEASURES

2. 1 of 5 DuraKore Powder Section 4 - First Aid Measures EMERGENCY AND FIRST AID PROCEDURES: EYES: If product gets in the eyes, flush with copious amounts of lukewarm water for at least 15 minutes. If irritation occurs, contact a physician. INGESTION: If ingested, do not induce vomiting. If product has been swallowed, drink plenty of water or milk IMMEDIATELY. If the patient is vomiting, continue to offer water or milk. Never give anything by mouth to an unconscious person. Provide an estimate of the time at which the material was ingested and the amount of the substance that was swa llowed. Get medical attention immediately. Section 4 - First Aid Measures Continued INHALATION: Remove to fresh air. Seek immediate medical attention. SKIN: If irritation occurs and product is on the skin, rinse thoroughly with lukewarm w ater, followed by a thorough washing of the effected area with soap and water. If irritation, redness or swelling persists, contact a physician immediately. CLOTHING: Remove contaminated clothing, wash thoroughly before reuse. TREATMENT: Tre at symptoms conventionally, after thorough decontamination. Section 5 - Fire Fighting Measures FLASH POINT: 304  C, 580  F FLAMMABLE LIMIT , AIR VOL% LOWER: NA UPPER: NA AUTOIGNITION TEMPERATURE: NE EXTINGUISHER METHOD: Water, carbon dioxide, dry chemical. FIRE AND EXPLOSION HAZARDS: Polymer dust is combustible. The explosive limits of the polymer particles suspended in air are approximately those of coal dust. SPECIAL FIRE FIGHTING PROCEDURES: Avoid extinguishin g methods, which may generate dust clouds. Water stream can disperse dust into air producing a fire hazard and possible explosion hazard if exposed to ignition source. EXPLOSION HAZARD: Firefighters should wear self - contained breathing apparatus. SENSITIVE TO MECHANICAL IMPACT: For Polymer: No. SENSITIVE TO STATIC DISCHARGE: For Polymer: No. Section 6 - Accidental Release Measures ACCIDENTAL RELEASE: Before cleaning any spill or leak, individuals involved must wear appropriate Personal Protective Equipment (e.g., goggles, gloves). Sweep up to avoid slipping hazard. Keep airborne particulates at a minimum when cleaning up spills. Dispose of properly in accordan ce with local, state and federal regulations. Wash all affected areas with plenty of warm water and soap. Remove any contaminated clothing and wash thoroughly before reuse. E

3. 1 of 5 DuraKore Powder Section 7 - Handling and Storage PRECAUTIONS FOR HANDLING: Use in well ventilated areas. Avoid contact with skin, eyes and clothing. Avoid breathing dust. Use good personal hygiene and housekeeping. PRECAUTIONS FOR STORAGE: Store containers in a cool, dry location, away from di rect sunlight, other l light sources, or sources of intense heat. Keep container closed to prevent water absorption and contamination. INDUSTRIAL HYGIENE PRACTICES: Avoid prolonged contact with the product. Use in a well - ventilated loc ation (e.g., local exhaust ventilation, fans). After use, wash hands and exposed skin with soap and water. Do not eat, drink or smoke while handling product. Section 8 - Exposure Controls, Personal Protection VENTILATION: When workin g with large quantities of product provide adequate ventilation (e.g., local exhaust ventilation, fans). Ensure that an eyewash station, sink or washbasin is available in case of exposure to eyes. Use good local exhaust at processing eq uipment, including buffers, sanders, grinders and polishers. Section 8 - Exposure Controls, Personal Protection Continued RESPIRATORY PROTECTION: No special respiratory protection is required under typical circumstances of use or handli ng. If necessary, use only respiratory protection authorized per U.S. OSHA's requirement in 29 CFR § 1910.134, or applicable U.S. state regulations, or the appropriate standards of Canada, its provinces, E.C. member states, or Austral ia. EYE PROTECTION: Depending on the use of this product, safety glasses or goggles may be worn. If necessary, refer to U.S. OSHA 29 CFR § 1910.133, Canadian standards, or the European Standard EN166. Ensure that an eyewash station, sink or washbasin is available in case of exposure to eyes. PROTECTIVE GLOVES: If anticipated that prolonged & repeated skin contact will occur during u se of this product, wear gloves for routine industrial use. If necessar y, refer to U.S. OSHA 29 CFR § 1910.138, the appropriate standards of Canada, of the E.C. member states. OTHER PROTECTIVE EQUIPMENT: No special body protection is required under typical circumstances of use and handling. If necessary, refer to appropriate standards of Canada, the E.C. member states, or U.S. OSHA. An eyewash station and a safety shower are recommended. High temperature processing equipment should be well ventilated. Section 9 - Physical and Chemical Properties APPEARANCE: Fine clear to pigmented powder. ODOR: Faint odor in bulk. pH: NA ODOR THRESHOLD: ND BOILING POINT: NA FREEZING POINT: NA

4. 1 of 5 DuraKore Powder VISCOSITY: NA SPECIFIC GRAVITY (H 2 O=1): ND VAPOR PRESSURE: NA PERCENT VOLATILE W/W%: NA VAPOR DENSITY (AIR=1): NA EVAPORATION RATE (BuAc =1): NA SOLUBILITY IN WATER: Insoluble. COEFFICIENT OF WATER/OIL DISTRIBUTION: ND Section 10 - Stability and Reactivity CONDITIONS TO AVOID: Heating above 240  C, 464  F. INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizing agents. HAZARDOUS DECOMPOSITION PRODUCTS: Methacrylate Monomer and Oxides of Carbon when burned. HAZARDOUS POLYMERIZATION: MAY OCCUR: WILL NOT OCCUR: X STABIL ITY: UNSTABLE: STABLE: X Section 11 - Toxicological Information TOXICITY DATA: This product has NOT been tested on animals to obtain toxicology data. There is toxicology data for the components of the product, which is found in scientific literature. This data has not been presented in this document. MUTAGENICITY DATA: This product is not reported to produce mutagenic effects in humans. Section 11 - Toxicological Information Continued REPRODUCTIVE TOXICITY DATA: Embryotoxicity: This product is not reported to produce embryotoxic effects in humans. Teratogenicity: This product is not reported to cause teratogenic effects in humans. Reproductive Toxicity: This product is not reported to cause reproductive effects in humans. S ection 12 - Ecological Information AQUATIC TOXICITY: There is no specific data available for this product; however, very large releases of this product may be harmful or fatal to overexposed aquatic life. ENVIRONMENTAL FATE: There is no specific data available for this product. Section 13 - Disposal Considerations WASTE DISPOSAL METHOD: Dispose of properly in accordance with Federal, State, and Local regulations. DISPOSAL OF EMPTY CONTAINERS: Reuse of empty drums or containers is not recommended. Employees should be advised of the potential hazards due to residual material associated with empty containers. Dispose of all empty containers proper ly in accordance with Federal, State and Local regula tions.

Views

  • 323 Total Views
  • 253 Website Views
  • 70 Embeded Views

Actions

  • 0 Social Shares
  • 0 Likes
  • 0 Dislikes
  • 0 Comments

Share count

  • 0 Facebook
  • 0 Twitter
  • 0 LinkedIn
  • 0 Google+

Embeds 1

  • 17 www.reliancedental.net