SDS_2016_Dura_Rely-A-Soft_Liquid

Public Channel / SDS

Share on Social Networks

Share Link

Use permanent link to share in social media

Share with a friend

Please login to send this document by email!

Embed in your website

Select page to start with

Post comment with email address (confirmation of email is required in order to publish comment on website) or please login to post comment

5. 5 of 5 Dura Rely - A - Soft Liquid Section 15 - Regulatory Information Continued FDA: 21 CFR 175.105, 176.170, 176.180, 175.300, 175.320, 175.380, 175.390, 177.1210, 181.27 Subject to provisions of these regulations. The final fo rmulator is responsible for complying with any limitations listed in specific sections. STATE REGULATIONS: This product or its ingredients have been evaluated for New Jersey, Pennsylvania, and California Prop 65 supplier notification requirement s. Substances that are subject to notification requirements, if any are listed below. Canadian WHMIS WHMIS Hazard Class: D2B Toxic Materials. Components WHMIS Ingredient Disclosure Section 16 - Additional Information NATIONAL FIRE PROTECTION ASSOCIATION (NFPA) HAZARD IDENTIFICATION RATING: HEALTH: 1 Fire: 1 Physical Hazard: 0 ABBREVIATIONS: NA: Not Applicable ND: Not Determined NE: Not Established ppm: parts per million G: Gallon mg: Milligram L: L iter gm: Gram mol: Mole kg: Kilogram μ: Micro mm: Millimeter p Pico Pa: Pascals LC: Lethal Concentration LD: Lethal Dose TC: Toxic Concentration TD: Toxic Dose BOD: Biological Oxygen Demand COD: Chemical Oxygen Demand Lo: Lowest ThOD: Theoretical Oxygen Demand Tlm: Threshold Limit H: Hours M: Months D: Days Y: Years W: Weeks ACGIH: American Conference of Governmental Industrial Hygienist CPR: Controlled Product’s Regulation DSL: Canadian Domestic Substances List ND SL: Canadian Non - domestic Substance List IARC: International Agency for Research for Cancer NOEL: No Observed Effect Level NOAEL: No Observed Adverse Effect Level OSHA: Occupational Safety and Health Administration PEL: Permissible Exposure Limit TLV: Threshold Limit Value THIS MATERIAL SAFETY DATA SHEET IS PREPARED IN COMPLIANCE WITH FEDERAL REGULATIONS (29 CFR 1910.1200), THE COMMONWEALTH OF PENNSYLVANIA REGULATIONS (TITLE 34. CHAPTERS 301 - 323) AND CANADIAN WHMIS REGULATIONS, ANY APPLICABLE STATE A ND LOCAL REGULATIONS SHOULD BE CONSULTED. THE ABOVE INFORMATION MAY BE BASED IN PART ON INFORMATION PROVIDED BY COMPONENT SUPPLIERS AND IS BELIEVED TO BE CORRECT AS OF THE DATE HEREOF. HOWEVER, NO WARRANTY OF MERCHANTABILITY, FITNESS FOR ANY USE, OR ANY OT HER WARRANTY IS EXPRESSED OR IS TO BE IMPLIED REGARDING THE ACCURACY OF THESE DATA, THE RESULTS TO BE OBTAINED FROM THE USE OF THE MATERIAL, OR THE HAZARDS CONNECTED WITH SUCH USE. SINCE THE INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYO ND OUR CONTROL AND WITH WHICH WE MAY BE UNFAMILIAR, AND SINCE DATA MADE AVAILABLE SUBSEQUENT TO THE DATE HEREOF MAY SUGGEST MODIFICATION OF THE INFORMATION, WE ASSUME NO RESPONSIBILITY FOR THE RESULT OF ITS USE. THIS INFORMATION AND MATERIAL IS FURNISHED O N THE CONDITION THAT THE PERSON RECEIVING IT SHALL MAKE HIS/HER OWN DETERMINATION AS TO THE SUITABILITY OF THE MATERIAL FOR HIS/HER PARTICULAR PURPOSE AND ON THE CONDITION THAT HE/SHE ASSUME THE RISK OF HIS/HER USE THEREOF. Revised April 4, 2016

4. 4 of 5 Dura Rely - A - Soft Liquid Section 12 - Ecological Information AQUATIC TOXICITY: Information given is based on data on the components and the ecotoxicology of similar products. Santicizer 141 Ecotoxicity - Fish Species Data:>0.38 mg/L LC50 Lepomis marchers 96 h>0.38 mg/L LC50 Oncorhynchus mykiss 96 h > 0.38 mg/L LC50 Pimephales promelas 96hEcotoxicity - Water Flea Data: = 0.15 mg/L EC50 Daphnia Magna 48 h Ecotoxicity - Freshwater Algae Data: = 0.2 mg/L EC50 Selenastrum capricornutum 72 h Ethyl Acetate 96 Hr LC50 Pimephales promelas: 230 mg/L(flow - through); 96 Hr LC50 Oncorhynchus mykiss: 484 mg/L (flow - through); 48 Hr EC50 Daphnia magna (water flea): 717 mg/L;48 Hr EC50 Scenedesmus subspicatus (algae): 3300 mg/L. Eth yl Alcohol 96 Hr LC50 Pimephales promelas: 230 mg/L(flow - through); 96 Hr LC50 Oncorhynchus mykiss: 484 mg/L (flow - through); 48 Hr EC50 Daphnia magna (water flea): 717 mg/L;48 Hr EC50 Scenedesmus subspicatus (algae): 3300 mg/L. Persis tence and Degradability: Not determined. Section 13 - Disposal Considerations Waste from residues / unused products: Waste must be disposed of in accordance with Federal, State and Local regulations. Where possible , recycling i s preferred to disposal or incineration. Section 14 - Transport Information DOT (U.S.) UN/ID No.: UN3082 Proper Shipping Name: Environmentally hazardous substances, liquid, n.o.s. U.S. DOT - Hazard Class: 9 Packing group: III Other shipping information: This material meets the definition of a severe marine pollutant. Applies to containers for shipments in bulk or via water transportation. Do not apply this DOT severe marine pollutant information to any ground mode less than 119 gallons. TDG (Cana da), UN/ID No.: UN3082 Proper Shipping Name: Environmentally hazardous substances, liquid, n.o.s. Class: 9 Packing group: III Section 15 - Regulatory Information U.S. REGULATIONS: Not subject to the provisions of SARA 313 Title III Not subject to TSCA 12(b) Export Notification

3. 3 of 5 Dura Rely - A - Soft Liquid Section 9 - Physical and Chemical Properties Color: Colorless Odor: Odorless Physical State: Liquid pH: No Data Available Molecular Weight: No Data Available BOILING POINT: 239.0 @ 13hPa; 375°C @ 1.013 hPa Melting Point/Range: No Data Available Specific Gravity (H2O=1): 1.089 Vapor Pressure: 0.26 hPa @ 150°C Evaporation Rate (H2O=1): < 1.00 Water Solubility (mg/l): 0.31 Partition Coefficient: 5.3x10 exp5 VOC Content (%): 2.50 % Viscosity (cP): 16.4 mPa.s @ 25°C Refractive Index: 1.508 - 1.512 @ 20°C Section 10 - Stability and Reactivity Stability: Stable at normal conditions. Polym erization: Will not occur. Hazardous Decomposition products: None under normal use. Materials to Avoid: None Known. Conditions to avoid: None known. Section 11 - Toxicological Information Toxicity: Santicizer 141: LD50 (oral, rat) > 15800 mg/kg LD50 (Dermal Rabbit) >7940 mg/kg Ethyl Acetate: Ethyl Acetate vapor is irritating to the eyes and respiratory passages of man at concentrations above 400 ppm. In animals it has a narcotic effect at concentrations of over 5000 ppm. Due to its irritating properties, employees will not voluntarily remain in such high concentrations. Repeated exposures of rabbits to 4450 ppm for 1 hour daily for 40 days resulted in anemia with leukocytosis, and damage to liver and kidneys. Animals exposed to lethal concentrations died with pulmonary edema and hemorrhage. This substance is a defatting agent, and prolonged exposure may cause irritation of the skin. Painful conjunctival irritation may occur from splashe s in the eye. No chronic systemic effects have been reported in humans. Ethyl Alcohol LD50 (oral, rat) 7060 mg/kg LD50 (intravenous, rat) 1440 mg/kg LC50 (inhalation, rat 20000 ppm/10H LDlo (skin, rabbit) 20 g/k g

2. 2 of 5 Dura Rely - A - Soft Liquid Section 5 - Fire Fighting Measures FLASH POINT: 223 °C, 433 °F METHOD: COC SUITABLE EXTINGUISHING M EDIA: Use dry chemical, CO2, water spray or “alcohol” foam. HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition can lead to release of irritating gases and vapors. Carbon oxides. Oxides of phosphorus. SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHT ERS: As in any fire, wear self - contained breathing apparatus (pressure - demand, NIOSH approved or equivalent) and full protective gear. UNUSUAL HAZARDS: None known. Section 6 - Accidental Release Measures Personal Precautions: Evacuate area of all unnecessary personnel. Avoid contact with skin, eyes and clothing. Use personal protective equipment. Environmental Precautions: Prevent further leakage or spillage if safe to do so. Prevent product from entering drains. Do not flush into surface water or sanitary sewer system. Methods for cleaning up: Soak up with inert absorbent mater (e.g. sand, silica gel, acid binder, universal binder, sawdust). Pick up and transfer to properly labeled contain ers. Dispose of promptly. Clean contaminated surface thoroughly. E Section 7 - Handling and Storage Handling: Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin, eyes and clothing. In ca se of insufficient ventilation, wear suitable respiratory equipment. Storage: Keep container tightly closed in a dry and well - ventilated place . Section 8 - Exposure Controls, Personal Protection Components OSHA ACGIH 01 Santicizer 141 Not Established Not Established 02 Ethyl Acetate Not Established Not Established 03 Ethyl Alcohol Not Established Not Established Engineering measures: Ensure adequate ventilation, especially in confined areas. Ensure that eyewash stations and safety showers are proximal to the work - station location. Eye Protection: Safety glasses with side - shields. Skin and Body Protection: Lightweight protective clothing. Wear chemically protective gloves, la b coat or apron to prevent prolonged or repeated skin contact. Hand Protection: Impervious gloves. Respiratory Proctection: Use NIOSH approved respirator when ventilation is inadequate. Hygiene Measures: Avoid contact with skin, eyes and clot hing. Wash hands before breaks and at the end of workday.

1. 1 of 5 Dura Rely - A - Soft Liquid Safety Data Sheet Section 1 - Chemical Product and Company Identification Product Name: Dura Rely - A - Soft Liquid Company Identification: Reliance Dental Mfg., LLC. 5805 W. 117 th Place Alsip, IL 60803 For Product Information, call: 708 - 597 - 6694 For Medical Information, call: 800 - 535 - 5053 Section 2 - Hazards Identification EMERGENCY OVERVIEW: Caution, may cause respiratory tract, eye and skin irritation. Color: Colorless Physical state: Liquid Odor: Odorless NFPA 704 Health: 1 Fire: 1 Instability: 0 Potential Health Effects: Principle routes of exposure: Inhalation, ingestion, skin and eye contact. Eye: May cause slight irritation. Skin May cause irritation. Inhalation: May cause irritation of respiratory tract. Elevated processing temperatures may release toxic vapors that are harmful if inhaled. Ingestion: May irritate digestive tract. SECTION 4 - FIRST AID MEASU Section 3 - Composition, Information on Ingredients Item Chemical Name CAS # WT/WT% TWA (UNITS) PEL (UNITS) 01 Santicizer 141 1241 - 94 - 7 90 - 95% 5 mg/m3 5 mg/m3 02 Ethyl Acetate 141 - 78 - 6 <10 % 400 ppm 400 ppm 03 Ethyl Alcohol 64 - 17 - 5 <10 % 1000 ppm 1000 ppm Section 4 - First Aid Measures Eye Contact: Rinse immediately with plenty of water, also under the eyelids. Get medical attention if irritation develops. Skin Contact: Wash off immediately with soap and plenty of water. Remove and wash contaminated clothing before re - use. Get medical attention if irritation develops. Inhalation: Move to fresh air. IF breathing is difficult, give oxygen. If symptoms persist, call a physician. Ingestion: Drink plenty of water. Do not induce vomiting. Get medical attention if irritation develops .

Views

  • 398 Total Views
  • 312 Website Views
  • 86 Embeded Views

Actions

  • 0 Social Shares
  • 0 Likes
  • 0 Dislikes
  • 0 Comments

Share count

  • 0 Facebook
  • 0 Twitter
  • 0 LinkedIn
  • 0 Google+

Embeds 1

  • 14 www.reliancedental.net