SDS_2016_DuraTray_Powder

Public Channel / SDS

Share on Social Networks

Share Link

Use permanent link to share in social media

Share with a friend

Please login to send this document by email!

Embed in your website

Select page to start with

Post comment with email address (confirmation of email is required in order to publish comment on website) or please login to post comment

4. 4 of 4 DuraTray Powder Section 16 - Additional Information Continued ABBREVIATIONS: NA: Not Applicable ND: Not Determined NE: Not Established ppm: parts per million G: Gallon mg: Milligram L: Liter gm: Gram mol: Mole kg: Kilogram μ: Micro mm: Millimeter p Pico Pa: Pascals LC: Lethal Concentration LD: Lethal Dos e TC: Toxic Concentration TD: Toxic Dose BOD: Biological Oxygen Demand COD: Chemical Oxygen Demand Lo: Lowest ThOD: Theoretical Oxygen Demand Tlm: Threshold Limit H: Hours M: Months D: Days Y: Years W: Weeks ACGIH: American Conference of Governmental Industrial Hygienist CPR: Controlled Product’s Regulation DSL: Canadian Domestic Substances List NDSL: Canadian Non - domestic Substance List IARC: International Agency for Research for Cancer NOEL: No Observed Effect Level NOAEL: No Observed Adverse Effect Level OSHA: Occupational Safety and Health Administration PEL: Permissible Exposure Limit TLV: Threshold Limit Value THIS MATERIAL SAFETY DATA SHEET IS PREPARED IN COMPLIANCE WITH FEDERAL REGULATIONS (29 CFR 1910.1200), THE COMM ONWEALTH OF PENNSYLVANIA REGULATIONS (TITLE 34. CHAPTERS 301 - 323) AND CANADIAN WHMIS REGULATIONS, ANY APPLICABLE STATE AND LOCAL REGULATIONS SHOULD BE CONSULTED. THE ABOVE INFORMATION MAY BE BASED IN PART ON INFORMATION PROVIDED BY COMPONENT SUPPLIERS AND IS BELIEVED TO BE CORRECT AS OF THE DATE HEREOF. HOWEVER, NO WARRANTY OF MERCHANTABILITY, FITNESS FOR ANY USE, OR ANY OTHER WARRANTY IS EXPRESSED OR IS TO BE IMPLIED REGARDING THE ACCURACY OF THESE DATA, THE RESULTS TO BE OBTAINED FROM THE USE OF THE MATER IAL, OR THE HAZARDS CONNECTED WITH SUCH USE. SINCE THE INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL AND WITH WHICH WE MAY BE UNFAMILIAR, AND SINCE DATA MADE AVAILABLE SUBSEQUENT TO THE DATE HEREOF MAY SUGGEST MODIFICATION OF THE INFORMATION, WE ASSUME NO RESPONSIBILITY FOR THE RESULT OF ITS USE. THIS INFORMATION AND MATERIAL IS FURNISHED ON THE CONDITION THAT THE PERSON RECEIVING IT SHALL MAKE HIS/HER OWN DETERMINATION AS TO THE SUITABILITY OF THE MATERIAL FOR HIS/HER PART ICULAR PURPOSE AND ON THE CONDITION THAT HE/SHE ASSUME THE RISK OF HIS/HER USE THEREOF. Revised April 4, 2016

3. 3 of 4 DuraTray Powder Section 12 - Ecological Information Environmental Fate and Distribution: High tonnage material produced in partially contained systems. Solid with low volatility. The product is essentially insoluble in water. The product has low potential for bioaccumulation. The product is predicte d to have low mobility in soil. Persistence and degradation: The product is non - biodegradable in soil. There is no evidence of degradation in soil and water. Toxicity: The product is predicted to have now toxicity to aquatic organisms. Effect on Effluent Treatment: The product is anticipated to be poorly removed in biological treatment processes. Section 13 - Disposal Considerations WASTE DISPOSAL METHOD: Non - hazardous waste. May be disposed of in landfill or incinerated. Follow Federal, State, and Local regulations for disposal. Section 14 - Transport Information NON - HAZARDOUS SHIPPING NAME: SYNTHETIC GUM RESIN GRANULAR, NOIBN Section 15 - Regulatory Information RISK STATEMENTS: R36/37 - Irritating to eyes, respiratory system. R43 - May cause sensitization by skin contact. SAFETY STATEMENTS: S3 - Keep in a cool place. S7/8 - Keep container tightly closed and dry. S 20/21 - When using do not eat, drink or smoke. S22 - Do not breathe dust. S24/25 - Avoid contact with skin and eyes. S37/39 - Wear suitable gloves and eye/face protection. CANADIAN REGULATIONS: WHMIS: This product has been classified in accordance with the hazardous criteria of the CPR and the SDS contains all the information required by the CPR. All of the components of the material are listed on the Canadian DSL. TSCCA: For use in FDA r egulated products only. Section 16 - Additional Information HAZARDOUS MATERIAL IDENTIFICATION SYSTEM (HMIS) RATING: HEALTH: 1 FLAMMABILITY: 1 REACTIVITY: 0

1. 1 of 4 DuraTray Powder Safety Data Sheet Section 1 - Chemical Product and Company Identification Product Name: DuraTray Powder Company Identification: Reliance Dental Mfg., LLC. 5805 W. 117 th Place Alsip, IL 60803 For Product Information, call: 708 - 597 - 6694 For Medical Information, call: 800 - 535 - 5053 Section 2 - Hazards Identification PRIMARY ROUTES OF ENTRY: Eyes or skin (no absorption); inhalation of dusts. Avoid inhalation of dust. Keep dust out of eyes to prevent possible irritation. POTENTIAL HEALTH EFFECTS: EYE: Dust may cause irritation. SKIN: Unlikely to cause skin irritation. INGESTION: Low oral toxicity. INHALATION: Unlikely to be hazardous but dust or vapors may cause irritation. CHRONIC INFORMATION: Resin contains traces of eth yl acryl ate, which is classified as an animal carcinogen. TERATOLOGY INFORMATION: No information but adverse effects unlikely. REPRODUCTIVE INFORMATION: No information but adverse effects unlikely. Section 3 - Composition, Information on Ingredient s Item Chemical Name CAS # WT/WT% 01 Poly (Methyl Methacrylate / Ethyl Acrylate 9010 - 88 - 2 < 65 02 Omprgamoc Filler 1317 - 65 - 3 > 35 Section 4 - First Aid Measures EMERGENCY AND FIRST AID PROCEDURES: EYES: Flush with water for 15 minutes, including under eyelids. Get medical help if discomfort persists. INGESTION: Do not induce vomiting. Rinse mouth out with water. Obtain medical attention if ill effects occur. INHALATION: Remove to fresh air. Get me dical help if discomfort persists. SKIN: Wash with soap and water. Get medical help if discomfort persists. Section 5 - Fire Fighting Measures FLASH POINT: 300  C, 572  F FLAMMABLE LIMIT , AIR VOL% LOWER: NA UPPER: NA AUTOIGNITION TEMPERATURE: NE EXTINGUISHER METHOD: Water, foam, carbon dioxide or dry powder. SPECIAL FIRE FIGHTING PROCEDURES: Avoid extinguishing methods, which may generate dust clouds. Water stream can disperse dust into air producing a fire hazard and possible explosion hazard if exposed to ignition source. UNUSUAL, FIRE & EXPLOSION HAZARD: Polymer dust is combustible. The explosive limits of the polymer particles suspended in air are approximately those of coal dust. Firefighters should wear self - contained breathing apparatus.

2. 2 of 4 DuraTray Powder Section 6 - Accidental Release Measures ACCIDENTAL RELEASE: Sweep up to avoid slipping hazard. Keep airborne particulates at a minimum when cleaning up spills. E Section 7 - Handling and Storage PRECAUTIONS FOR HANDLING: Use in well ventilated areas. Avoid contact with skin, eyes and clothing. Avoid breathing dust. Use good personal hygiene and housekeeping. PREC AUTIONS FOR STORAGE: Store containers in a cool, dry place away from incompatible materials. Keep container closed to prevent water absorption and contamination. STORAGE TEMPERATURE: Preferably not exceeding 35°C INDUSTRIAL HYGIENE PRACTICES: Wash face and hands thoroughly with soap and water after use and before eating, drinking, smoking or applying cosmetics. Section 8 - Exposure Controls, Personal Protection VENTILATION: Use good local exhaust at processing equipment. RESPIR ATORY PROTECTION: Use type for Particulates Not Otherwise Classified, if needed. EYE PROTECTION: Safety glasses or chemical splash goggles. INDUSTRIAL HYGIENE PRACTICES: Wash face and hands thoroughly with soap and water after use and before eating, drinking, smoking or applying cosmetics. Section 9 - Physical and Chemical Properties APPEARANCE: Fine powder. ODOR: Faint odor in bulk. BOILING POINT: NE SPECIFIC GRAVITY (H 2 O=1): 1.18 VAPOR PRESSURE: NE PERCENT VOLATILE W/W%: <1% VAPOR DENSITY (AIR=1) NE EVAPORATION RATE: NE SOLUBILITY IN WATER: NIL Section 10 - Stability and Reactivity HAZARDOUS DECOMPOSITION PRODUCTS: Methyl Methacrylate; ethyl acryl ate. HAZARDOUS REACTIONS: None known. H AZARDOUS POLYMERIZATION: Will not occur. Section 11 - Toxicological Information PRIMARY ROUTES OF ENTRY: Eyes or skin (no absorption); inhalation of dusts. EYE: Dust may cause irritation. SKIN: Unlikely to cause skin irritation. INGESTION: Low oral toxicity. INHALATION: Unlikely to be hazard by inhalation. High concentrations of dust may be irritant to the upper respiratory tract. High concentrations of vapor from hot operations may be harmful, cause irritation of the respiratory tract, and slight narcotic effects. LONG TERM EXPOSURE: This material has been in use for many years with no evidence of adverse effects. CARCINOGENICITY: None of these components of this materials are listed by IARC, NTP, OSHA or ACGH as carcinogens. TARGET ORGANS: For Polymer: None Listed. TOXICITY DATA: For Polymer: None Listed. RTECS - Not Listed. TSCA - Listed.

Views

  • 279 Total Views
  • 224 Website Views
  • 55 Embeded Views

Actions

  • 0 Social Shares
  • 0 Likes
  • 0 Dislikes
  • 0 Comments

Share count

  • 0 Facebook
  • 0 Twitter
  • 0 LinkedIn
  • 0 Google+

Embeds 1

  • 13 www.reliancedental.net